PURSUIT OS 315 Manual do Proprietário

OS 3151921271June 2007FISHING BOATS3901 St. Lucie Blvd.Ft. Pierce, Florida 34946© 2007 S2 Yachts, Inc.OS 315OWNER’S MANUAL

OS 31510Operator Notes

OS 315100BOATS CAN BE DAMAGED FROM IMPROPER LIFTING AND ROUGH HANDLING WHENBEING TRANSPORTED BY LIFT TRUCKS. CARE AND PROPER HANDLING PROCEDURESM

OS 315101PREPARING THE BOAT FOR STORAGE:• Remove the bilge drain plug(s), if installed.• Thoroughly wash the fiberglass exterior, especially the antif

OS 315102The shower/cabin drain sump system must be properly winterized. Clean debris from the drain and sump andflush for several minutes with f

OS 315103The air conditioner components must be properly winterized by following winterizing procedure in the airconditioner owner’s manual.The air co

OS 315104PLACING AN ELECTRIC OR FUEL BURNING HEATING UNIT IN THE BILGE AREA CANBE POTENTIALLY HAZARDOUS AND IS NOT RECOMMENDED.Proper storage is v

OS 315105• Clean and wash the boat.• Install all upholstery, cushions and canvas.AFTER LAUNCHING:• Carefully check all water systems and the engine bo

OS 315106Operator Notes

OS 315107GLOSSARY OF TERMSAft: In, near, or toward the stern of a boat.Aground: A boat stuck on the bottom.Amidships: In or toward the part of a bo

OS 315108Bridge: The area from which a boat is steered and controlled.Bridge Deck: A deck forward and usually above the cockpit deck.Broach: Wh

OS 315109EPIRB: Emergency Position Indicating Radio Beacon. Operates as a part of a worldwide satellite distresssystem.Even Keel: When a boat float

OS 31511Registration and NumberingFederal law requires that all undocumented vessels equipped with propulsion machinery be registered in thestate of p

OS 315110Helm: The steering and control area of a boat.Hull: The part of the boat from the deck down.Inboard: A boat with the engine mounted wi

OS 315111Moored: A boat secured with cables, lines or anchors.Mooring: An anchor permanently embedded in the bottom of a harbor that is used to secu

OS 315112Rubrail: Railing (often rubber or hard plastic) that runs along the boat’s sheer to protect the hull when comingalongside docks, piers,

OS 315113Swimming Ladder: Much the same as the boarding ladder except that it extends down into the water.Taffrail: Rail around the rear of the cock

OS 315114THIS PAGE WAS LEFT BLANKINTENTIONALLY

OS 315115Appendix B:MAINTENANCE SCHEDULE AND LOGMAINTENANCEEach UseWeeklyMonthlyEach SeasonYearlyAs NeededenilretawehtwoleblluhnaelCXlluhtniapmottoBXX

OS 315116HoursDate DealerService/RepairsMAINTENANCE LOG

OS 315117HoursDate DealerService/RepairsMAINTENANCE LOG

OS 315118HoursDate DealerService/RepairsMAINTENANCE LOG

OS 315119HoursDate DealerService/RepairsMAINTENANCE LOG

OS 31512USCG specifications and regulations relating to performance, construction, or materials. The equipmentrequirements vary according to the

OS 315120HoursDate DealerService/RepairsMAINTENANCE LOG

OS 315121Appendix C:BOATING ACCIDENT REPORTFORM APPROVEDOMB NO.211-0010DEPARTMENT OFTRANSPORTATIONU.S. COAST GUARDC.G. 1865 (REV. 1/88)The operator/ow

OS 315122If more than 3 fatalities and/or injuries, attach additional form(s)WAS VICTIM?[ ] Swimmer[ ] Non SwimmerDATE OFBIRTHADDRESSNAME DEATH

OS 315123Appendix D:Float Plan1. Name of person reporting and telephone number.2. Description of boat.Type Color TrimRegistration No. LengthName Make

OS 315124THIS PAGE WAS LEFT BLANKINTENTIONALLY

OS 315125Appendix E:TROUBLESHOOTINGGUIDE• Steering system is low on fluid. Fill and bleed system.• Steering system has air in it. Fill and bleed sys

OS 315126ENGINE PROBLEMSThe engine is running too hot.The engine alternator is not charging properly.The engine suddenly will not operate over 200

OS 315127• The strainer on the intake scoop is clogged preventingthe water from getting to the pump. Put the boat inreverse to clean the strainer.• T

OS 315128THIS PAGE WAS LEFT BLANKINTENTIONALLY

OS 31513TABLE OF CONTENTSIntroduction:Safety Information ...3Boat In

OS 31514Chapter 4: Electrical System4.1 General ...334.2

OS 31515Chapter 8: Interior Equipment8.1 Companionway Door...598.2 Mid-Berth ...

OS 31516Chapter 11: Routine Maintenance11.1 General ...91

OS 31517Chapter 1:PROPULSION SYSTEM1.1 GeneralThe Pursuit OS 315 is designed to be powered with twin 2-cycle or 4-cycle outboard motors.Each manufact

OS 31518DO NOT PAINT THE OUTBOARD MOTORS WITH ANTIFOULING PAINTS DESIGNED FORBOAT HULLS. MANY OF THESE PAINTS CAN CAUSE SEVERE DAMAGE TO THE EN-G

OS 315191.5 PropellersThe propellers convert the engine’s power into thrust. They come in a variety of styles, diameters and pitches.The one that wi

OS 3152THIS PAGE WAS LEFT BLANKINTENTIONALLY

OS 31520FUEL GAUGEThe fuel gauge indicates the amount of fuel in the fuel tanks. The fuel gauge switch, located on the helm,is used to switch the

OS 31521Chapter 2:HELM SYSTEMS2.1 GeneralThe helm controls consist of the engine throttle and shift controls, the steering system, the trim tab contr

OS 31522The handles of dual lever controls may not always align with each other at all RPM settings due to variationsin control cable routing, cab

OS 31523THE ENGINE HOSES AND CABLES OR THE TRANSOM GEL COAT CAN BE DAMAGEDBY TILTING THE ENGINES TO THE FULL UP POSITION WITH THE ENGINES TURNEDTO THE

OS 31524and is normal. Refer to the steering manufacturer owner’s manual for specific information on the steeringsystem.Dual engine outboards are

OS 31525Avoid depressing the switch while awaiting the trim plane reaction. By the time the effect is noticeablethe trim tab plane will have moved to

OS 31526DO NOT RUN THE BOW THRUSTER OUT OF THE WATER. THE MOTOR WILLOVERSPEED RESULTING IN DAMAGE TO THE UNIT AND INVALIDATE THE WAR-RANTY.2.12

OS 31527Chapter 3:FUEL SYSTEM3.1 GeneralThe fuel system used in Pursuit boats is designed to meet the requirements of the U.S. Coast Guard, theNatio

OS 31528DO NOT CONFUSE FUEL FILL DECK PLATES WITH THE WATER OR WASTE FILL DECKPLATES. THESE PLATES ARE ALSO LABELED ACCORDINGLY. IF GASOLINE OR D

OS 31529GASOLINE FUEL FILTERFuel filters are located in a locker in the aft starboard corner of thecockpit. The filters are the water separator type a

OS 3153SAFETY INFORMATIONYour Owner’s Manual has been written toinclude a number of safety instructions to assure the safeoperation and maintenance o

OS 315303.4 Fueling InstructionsFUEL IS VERY FLAMMABLE AND CAN CAUSE A FIRE OR AN EXPLOSION. BE CARE-FUL WHEN FILLING THE FUEL TANKS. NO SMOKIN

OS 31531SPILLED FUEL CAN CAUSE A FIRE OR AN EXPLOSION. MAKE SURE YOU DO NOTSPILL ANY FUEL. IF A SMALL AMOUNT OF FUEL IS SPILLED ON THE FIBERGLASS,US

OS 31532Diesel engine operation requires a good supply of clean, dry diesel fuel. Improper marina fuel storagetechniques, limited boat usage, etc

OS 31533Chapter 4:ELECTRICAL SYSTEM4.1 GeneralYour Pursuit is equipped with AC and 12-volt DC electrical systems. The AC system can draw current fr

OS 31534Main Distribution Panel:The Main Distribution Panel (MDP) is located on the end of the L-lounge. Twelve-volt power is distributedfrom the

OS 31535The following are descriptions of the functions controlled by the MDP:Battery Switches:There are two battery switches to manage the 12-volt po

OS 315364.3 12-Volt DC PanelsHELM SWITCH PANELSThe following are descriptions of the components con-trolled by the helm switches:HELM PANEL LEFTH

OS 31537HELM PANEL RIGHTAccThis is open and held for future additional accessories not to exceed 10 amps.HardtopActivates the red light mounted undern

OS 315384.4 AC SystemThe AC system is fed by the shore power outlet or by theoptional generator. It is wired totally separate from the12-volt DC

OS 31539KEEP CHILDREN AWAY FROM ANY ELECTRICAL CABLES OR EQUIPMENT AND AL-WAYS USE GROUNDED APPLIANCES ON BOARD YOUR BOAT.DISCONNECTING PROCEDURE FOR

OS 3154THIS PAGE WAS LEFT BLANKINTENTIONALLY

OS 31540circuit from the batteries to the charger. They are located on the DC distribution panel. Push to reset thebreakers. The internal fuses

OS 31541GENERATOR PANELThese switches control the starting, running,AC power selector and stopping of the genera-tor. The procedures may vary dependi

OS 31542sandpaper as required. Coating the battery posts and cable clamps with petroleum jelly or silicone grease willprotect them and reduce cor

OS 31543Chapter 5:PLUMBING SYSTEMS5.1 Fresh Water SystemGENERALThe fresh water system consists of a potable water tank, distribution lines and a dist

OS 31544the water heater and lines before activating the water heater breaker. Refer to the water heater owner’s manualfor additional information

OS 31545turned to the “OFF” position when the washdown is not in use.When activated, the pressure switch will automatically control the pump. As the

OS 315465.4 LivewellSeawater is provided to the livewell by a 12-volt circulating pump. This pump is designed to carry a constantflow of water t

OS 31547COCKPIT DRAINSYour Pursuit has two scupper drains located in the rear of the cockpit. Water is channeled away from all hatchesby a gutter dra

OS 31548FISHBOX AND COOLER DRAINSAll of the compartments and drain rails are drained overboard by an automatic sump pump system. The pumpis acti

OS 31549The following items should be done routinely to maintain your fresh water system:• Remove the filter screens from the faucet spouts and elimin

OS 3155BOAT INFORMATIONPlease fill out the following information section and leave it in your PursuitOwner’s Manual. This information will be import

OS 31550DRAINAGE SYSTEMSIt is essential that the following items be done periodically to maintain proper drainage of your boat:• Clean the cockpit

OS 31551Chapter 6:VENTILATION SYSTEM6.1 Cabin VentilationVentilation to the cabin is provided by deck hatches and opening port windows.PORT LITESThe

OS 315526.5 Maintenance• Periodically lubricate all hinges and latch assemblies with a light oil.• Periodically clean and coat gasket materials w

OS 31553Chapter 7:EXTERIOR EQUIPMENT7.1 DeckRAILS AND DECK HARDWAREThe rail system and hardware fittings have been selected and installed to perform

OS 31554THE ANCHOR MUST BE POSITIONED SO IT DOES NOT REST AGAINST THE HULLSIDES AND BE PROPERLY SECURED AT ALL TIMES WHEN IT IS STORED IN THE AN-C

OS 31555Refer to the Windshield Ventilation section of the Ventilation System chapter and the 12-Volt DC Panelssection of the Electrical System chapte

OS 31556TRANSOM DOORThe transom door should only be operated when the boat is not in motion. The door must be latched in eitherthe full “OPEN” or

OS 31557Once the clear connector is completely installed, the side curtains can be put on. Slide the side curtains intothe slide tracks on the sides

OS 31558Operator Notes

OS 31559Chapter 8:INTERIOR EQUIPMENT8.1 Companionway DoorThe cabin is accessed through a sliding door. A lockable latch securesthe door in the close

OS 3156Operator Notes

OS 31560small amount of water to remain in the bowl after flushing.The waste is transferred into the holding tank where it remains until it is pum

OS 31561THE HEAD AND MACERATOR DISCHARGE SYSTEMS MUST BE PROPERLY WINTER-IZED BEFORE WINTER LAY-UP. SEE THE SECTION ON WINTERIZING.8.4 GalleyThe gal

OS 315628.5 Convertible V-Berth and TableThe V-berth is equipped with a table mounted on a removable support leg that allows the dinette to be co

OS 31563AIR CONDITIONERS USE SURFACE WATER AS COOLING MEDIUM. THE BOAT MUSTBE IN THE WATER AND THE RAW WATER SUPPLY SYSTEM MUST BE PROPERLY AC-TIVATE

OS 31564Operator Notes

OS 31565Chapter 9:SAFETY EQUIPMENT9.1 GeneralYour boat and outboard engines have been equipped with safety equipment designed to enhance the safeoper

OS 315669.3 Neutral Safety SwitchEvery control system has a neutral safety switch incorporated into it. This device prohibits the engines frombe

OS 31567IF ACTIVATION SHOULD OCCUR, IMMEDIATELY SHUT DOWN ALL ENGINES. TURNOFF ALL ELECTRICAL SYSTEMS, POWERED VENTILATION AND EXTINGUISH ALLSMOKING

OS 31568ALWAYS MAKE SURE THE BATTERY SWITCH IS "ON" AND THE POWER LIGHT ONTHE CARBON MONOXIDE DETECTOR IS LIT WHENEVER THE CABIN IS OCCU

OS 31569moved to an area of fresh air. Have thevictim breath deeply and seek immedi-ate medical attention. To learn moreabout CO poisoning, contact

OS 3157CERTIFICATIONS & SPECIFICATIONS(For Export Only)Manufacturer:NameAddressZip Code:Identification Numbers:Hull Identification NumberEngine Se

OS 315709.7 First AidIt is the operator's responsibility to be familiar with the proper first-aidprocedures and be able to care for minor in

OS 31571VISUAL DISTRESS SIGNALS:All Pursuit boats used on coastal waters, the Great Lakes, territorial seas, and those waters connected directlyto the

OS 31572FIRE EXTINGUISHERS:Pursuit Boats provides locations for two fire extinguishers on boats under 26 feet. Boats over 26 feet haveprovisions

OS 315739.9 Additional Safety EquipmentBesides meeting the legal requirements, prudent boaters carry additional safety equipment. This is particular

OS 31574Operator Notes

OS 31575Chapter 10:OPERATION10.1 GeneralBefore you start the engines on your Pursuit, you should have become familiar with the various componentsyst

OS 3157610.2 Homeland Security RestrictionsRecreational boaters have a role in keeping our waterways safe and secure. Violators of the restricti

OS 31577MEETING HEAD-ON OR NEARLY-SO SITUA-TIONSWhen two motor boats are approaching each other head-on or nearly head-on, neither boat has the right

OS 31578THERE MUST BE AT LEAST ONE PERSONAL FLOTATION DEVICE ON BOARD FOR EV-ERY PERSON ON BOARD AND ONE THROW-OUT FLOTATION DEVICE. CHECK THEU.S

OS 31579• Be sure the emergency stop lanyard is attached to the operator and the stop switch.VAPORIZING LIQUID EXTINGUISHERS GIVE OFF TOXIC FUMES; USE

OS 3158Operator Notes

OS 31580• Avoid sea conditions that are beyond the skill and experience of you and your crew.MAKE SURE ONE OTHER PERSON ON THE BOAT IS INSTRUCTED

OS 31581• Check the bilge area for debris and excess water.• Fill the fuel tanks to near full to reduce condensation. Allow enough room in the tanks

OS 31582• Be careful when using the trim tabs from the tower. The reaction of the trim tabs will be exaggeratedin the tower. Use small tab corre

OS 31583Dock lines are generally twisted or braided nylon. Nylon is strong and stretches to absorb shock. It also hasa long life and is soft and eas

OS 31584LEAVING A MOORINGStart the engines and let them warm up for several minutes before releasing the mooring line. The boat willalready be he

OS 31585stabilized, thoroughly inspect the boat for damage. Check below decks for leaks and the control systems forproper operation. Plug all leaks

OS 31586If the boat becomes swamped and capsizes, you and your passengers should stay with the boat as long as youcan. It is much easier for the

OS 31587• Make sure the trailer is a match for your boat’s weight and hull design. More damage can be done to aboat by the stresses of road travel th

OS 31588MAKE SURE YOUR TOWING VEHICLE AND TRAILER ARE IN COMPLIANCE WITH ALLSTATE AND LOCAL LAWS. CONTACT YOUR STATE MOTOR VEHICLE BUREAU FORLAWS

OS 31589• Immediately stop the boat and sound a man overboard alarm and have all passengers point to the personin the water. • Circle around quickly a

OS 3159Warranty and Warranty Registration CardsThe Pursuit Limited Warranty Statement is included with your boat. It has been written to be clearly s

OS 31590Operator Notes

OS 31591Chapter 11:ROUTINE MAINTENANCE11.1 GeneralBEFORE USING A CLEANING PRODUCT, REFER TO THE PRODUCT DIRECTIONS ANDSPECIFICATIONS.IF URETHANE FOAM

OS 31592Do not allow the hull antifouling paint to contact the outboard motor. Most antifouling paints designed for hullbottoms contain copper an

OS 31593USE EXTREME CARE WHEN WALKING ON WET GELCOAT SURFACES AS THEY ARESLIPPERY.STAINLESS STEEL HARDWAREWhen using the boat in saltwater, the hardwa

OS 31594YOU SHOULD CONTACT PURSUIT CUSTOMER RELATIONS BEFORE MAKING ANYMODIFICATIONS TO ALUMINUM FABRICATIONS. UNAUTHORIZED MODIFICATIONSCAN VOID

OS 31595becomes heavy enough to settle out of the gasoline to the bottom of the tank. Since the fuel pick up tube isvery near the bottom of the tank,

OS 31596Stronger cleaners, detergents and solvents may be effective in stain removal, but can cause either immediatedamage or slow deterioration.

OS 31597CARBON MONOXIDE IS A LETHAL, TOXIC GAS THAT IS COLORLESS AND ODORLESS.IT IS A DANGEROUS GAS THAT WILL CAUSE DEATH IN CERTAIN LEVELS.11.4 Cabi

OS 31598Operator Notes

OS 31599Chapter 12:SEASONAL MAINTENANCE12.1 Storage and Lay-upBEFORE HAULING:• Pump out the head. Flush the holding tank using clean soap, water and