PURSUIT 3480 Drummond Runner Manual do Proprietário

3480 DRUMMOND RUNNER13480 Drummond RunnerOWNER’S MANUAL921235, Revision AJanuary 2006FISHING BOATS3901 St. Lucie Blvd.Ft. Pierce, Florida 34946

3480 DRUMMOND RUNNER10Operator Notes

3480 DRUMMOND RUNNER100Operator Notes

3480 DRUMMOND RUNNER101Chapter 12:SEASONAL MAINTENANCE12.1 Storage and Lay-upBEFORE HAULING:• Pump out the head. Flush the holding tank using clean

3480 DRUMMOND RUNNER102BOATS CAN BE DAMAGED FROM IMPROPER LIFTING AND ROUGH HANDLING WHENBEING TRANSPORTED BY LIFT TRUCKS. CARE AND PROPER HANDLI

3480 DRUMMOND RUNNER103PREPARING THE BOAT FOR STORAGE:• Remove the bilge drain plug(s), if installed.• Thoroughly wash the fiberglass exterior, especi

3480 DRUMMOND RUNNER104The shower/cabin drain sump system must be properly winterized. Clean debris from the drain and sump andflush for several

3480 DRUMMOND RUNNER105The air conditioner components must be properly winterized by following winterizing procedure in the airconditioner owner’s man

3480 DRUMMOND RUNNER106PLACING AN ELECTRIC OR FUEL BURNING HEATING UNIT IN THE BILGE AREA CANBE POTENTIALLY HAZARDOUS AND IS NOT RECOMMENDED.Prope

3480 DRUMMOND RUNNER107• Clean and wash the boat.• Install all upholstery, cushions and canvas.AFTER LAUNCHING:• Carefully check all water systems and

3480 DRUMMOND RUNNER108Operator Notes

3480 DRUMMOND RUNNER109GLOSSARY OF TERMSAft: In, near, or toward the stern of a boat.Aground: A boat stuck on the bottom.Amidships: In or toward th

3480 DRUMMOND RUNNER11Registration and NumberingFederal law requires that all undocumented vessels equipped with propulsion machinery be registered in

3480 DRUMMOND RUNNER110Bridge: The area from which a boat is steered and controlled.Bridge Deck: A deck forward and usually above the cockpit de

3480 DRUMMOND RUNNER111EPIRB: Emergency Position Indicating Radio Beacon. Operates as a part of a worldwide satellite distresssystem.Even Keel: Whe

3480 DRUMMOND RUNNER112Helm: The steering and control area of a boat.Hull: The part of the boat from the deck down.Inboard: A boat with the eng

3480 DRUMMOND RUNNER113Moored: A boat secured with cables, lines or anchors.Mooring: An anchor permanently embedded in the bottom of a harbor that i

3480 DRUMMOND RUNNER114Rubrail: Railing (often rubber or hard plastic) that runs along the boat’s sheer to protect the hull when comingalongside

3480 DRUMMOND RUNNER115Swimming Ladder: Much the same as the boarding ladder except that it extends down into the water.Taffrail: Rail around the re

3480 DRUMMOND RUNNER116THIS PAGE WAS LEFT BLANKINTENTIONALLY

3480 DRUMMOND RUNNER117Appendix B:MAINTENANCE SCHEDULE AND LOGMAINTENANCEEach UseWeeklyMonthlyEach SeasonYearlyAs NeededenilretawehtwoleblluhnaelCXllu

3480 DRUMMOND RUNNER118HoursDate DealerService/RepairsMAINTENANCE LOG

3480 DRUMMOND RUNNER119HoursDate DealerService/RepairsMAINTENANCE LOG

3480 DRUMMOND RUNNER12USCG specifications and regulations relating to performance, construction, or materials. The equipmentrequirements vary acc

3480 DRUMMOND RUNNER120HoursDate DealerService/RepairsMAINTENANCE LOG

3480 DRUMMOND RUNNER121HoursDate DealerService/RepairsMAINTENANCE LOG

3480 DRUMMOND RUNNER122HoursDate DealerService/RepairsMAINTENANCE LOG

3480 DRUMMOND RUNNER123Appendix C:BOATING ACCIDENT REPORTFORM APPROVEDOMB NO.211-0010DEPARTMENT OFTRANSPORTATIONU.S. COAST GUARDC.G. 1865 (REV. 1/88)T

3480 DRUMMOND RUNNER124If more than 3 fatalities and/or injuries, attach additional form(s)WAS VICTIM?[ ] Swimmer[ ] Non SwimmerDATE OFBIRTHADDR

3480 DRUMMOND RUNNER125Appendix D:Float Plan1. Name of person reporting and telephone number.2. Description of boat.Type Color TrimRegistration No. Le

3480 DRUMMOND RUNNER126THIS PAGE WAS LEFT BLANKINTENTIONALLY

3480 DRUMMOND RUNNER127Appendix E:TROUBLESHOOTINGGUIDE• Steering system is low on fluid. Fill and bleed system.• Steering system has air in it. Fill

3480 DRUMMOND RUNNER128ENGINE PROBLEMSThe engine is running too hot.The engine alternator is not charging properly.The engine suddenly will not op

3480 DRUMMOND RUNNER129• The strainer on the intake scoop is clogged preventingthe water from getting to the pump. Put the boat inreverse to clean th

3480 DRUMMOND RUNNER13TABLE OF CONTENTSIntroduction:Safety Information ...

3480 DRUMMOND RUNNER130THIS PAGE WAS LEFT BLANKINTENTIONALLY

3480 DRUMMOND RUNNER14Chapter 4: Electrical System4.1 General ...

3480 DRUMMOND RUNNER15Chapter 8: Interior Equipment8.1 Companionway Door...638.2 H

3480 DRUMMOND RUNNER16Chapter 11: Routine Maintenance11.1 General ...

3480 DRUMMOND RUNNER17Chapter 1:PROPULSION SYSTEM1.1 GeneralThe Pursuit 3480 Drummond Runner is designed to be powered with twin 2-cycle or 4-cycle ou

3480 DRUMMOND RUNNER18DO NOT PAINT THE OUTBOARD MOTORS WITH ANTIFOULING PAINTS DESIGNED FORBOAT HULLS. MANY OF THESE PAINTS CAN CAUSE SEVERE DAMA

3480 DRUMMOND RUNNER191.5 PropellersThe propellers convert the engine’s power into thrust. They come in a variety of styles, diameters and pitches.Th

3480 DRUMMOND RUNNER2THIS PAGE WAS LEFT BLANKINTENTIONALLY

3480 DRUMMOND RUNNER20FUEL GAUGEThe fuel gauge indicates the amount of fuel in the fuel tanks. The engine instrumentation has a feature thatallo

3480 DRUMMOND RUNNER21Chapter 2:HELM SYSTEMS2.1 GeneralThe helm controls consist of three systems: the engine throttle and shift controls, the stee

3480 DRUMMOND RUNNER22start position just long enough to briefly engage the starter for the engine. Do not hold the key in the startposition long

3480 DRUMMOND RUNNER232.6 Engine Stop SwitchWE STRONGLY RECOMMEND THAT THE LANYARD BE ATTACHED TO THE DRIVERWHENEVER THE ENGINES ARE RUNNING.Your Purs

3480 DRUMMOND RUNNER24DO NOT ATTEMPT TO ADJUST THE HELM WHEEL POSITION WHILE UNDERWAY.2.8 Trim TabsThe trim tabs are recessed into the hull under

3480 DRUMMOND RUNNER252.10 Control Systems MaintenanceCONTROL MAINTENANCEPeriodic inspection of the control systems and all connections should be made

3480 DRUMMOND RUNNER26Operator Notes

3480 DRUMMOND RUNNER27Chapter 3:FUEL SYSTEM3.1 GeneralThe fuel system used in Pursuit boats is designed to meet the requirements of the U.S. Coast G

3480 DRUMMOND RUNNER28DO NOT CONFUSE FUEL FILL DECK PLATES WITH THE WATER OR WASTE FILL DECKPLATES. THESE PLATES ARE ALSO LABELED ACCORDINGLY. IF

3480 DRUMMOND RUNNER29GASOLINE FUEL FILTERFuel filters are located under the aft seat and accessed through a hatch.Fuel primers are built into the top

3480 DRUMMOND RUNNER3SAFETY INFORMATIONYour Owner’s Manual has been written toinclude a number of safety instructions to assure the safeoperation and

3480 DRUMMOND RUNNER30To fill the fuel tank at a marina, follow this procedure:1. Make sure all switches are in the “Off” position.2. Make sure th

3480 DRUMMOND RUNNER313.5 Fuel System MaintenancePERIODICALLY INSPECT ALL PRIMER BULBS, CONNECTIONS, CLAMPS AND HOSESFOR LEAKAGE AND DAMAGE OR DETERI

3480 DRUMMOND RUNNER32Operator Notes

3480 DRUMMOND RUNNER33Chapter 4:ELECTRICAL SYSTEM4.1 GeneralYour Pursuit is equipped with AC and 12-volt DC electrical systems. The AC system can d

3480 DRUMMOND RUNNER34Parallel Switch: Connects the batteries together forengine starting or charging of all batteries.Voltage Sensitive Relay (V

3480 DRUMMOND RUNNER35BATTERY SWITCHESThere are three battery switches and two parallel switches to manage the 12-volt power distribution.The Port Sta

3480 DRUMMOND RUNNER36Aft Stbd BilgeActivates the aft starboard bilge pump.Hardtop LightsActivating this button activates the lights mounted under

3480 DRUMMOND RUNNER37Island LightsActivates the lights mounted under the hardtop to illuminate the island surface.Island Accent LightsActivates the a

3480 DRUMMOND RUNNER38CARBON MONOXIDE IS A LETHAL, TOXIC GAS THAT IS COLORLESS AND ODORLESS.IT IS A DANGEROUS GAS THAT WILL CAUSE DEATH IN CERTAIN

3480 DRUMMOND RUNNER394.5 AC SystemThe AC system is fed by the shore power outlet or by the optional generator. It iswired totally separate from the

3480 DRUMMOND RUNNER4THIS PAGE WAS LEFT BLANKINTENTIONALLY

3480 DRUMMOND RUNNER40DO NOT ATTEMPT TO CORRECT THE WIRING YOURSELF. ELECTRIC SHOCK CANCAUSE SEVERE INJURY OR EVEN DEATH. ALWAYS HAVE A QUALIFIE

3480 DRUMMOND RUNNER41Reverse Polarity Light Test SwitchThere is a momentary switch located below the reverse polarity light in the AC breaker panel.

3480 DRUMMOND RUNNER424.6 Generator (Optional)Your Pursuit may be equipped with an optional generator. An owner operator's manual for the g

3480 DRUMMOND RUNNER43lubricant like petroleum jelly or silicone grease. The sockets should be sprayed with a protector. Care mustbe taken not to ge

3480 DRUMMOND RUNNER44important factors to the generator's longevity are proper ventilation, maintenance of the fuel system, ignitionsystem,

3480 DRUMMOND RUNNER45Chapter 5:PLUMBING SYSTEMS5.1 Fresh Water SystemGENERALThe fresh water system consists of a potable water tank, distribution li

3480 DRUMMOND RUNNER46WATER HEATERThe water heater is located in the cockpit island behind the port side storage cabinet. All heaters have an ACe

3480 DRUMMOND RUNNER47OPERATIONA high pressure pump, controlled by a pressure sensor, supplies the raw water hoseconnector located in the cockpit. T

3480 DRUMMOND RUNNER48The pump, the strainer and seacock are located in the cockpit machinery space.Please refer to the air conditioner owner&apos

3480 DRUMMOND RUNNER49A LOOSE DRAIN PLUG WILL ALLOW SEA WATER TO ENTER THE BILGE AND COULDCAUSE THE BOAT TO SINK. IT IS VERY IMPORTANT TO CHECK THE D

3480 DRUMMOND RUNNER5BOAT INFORMATIONPlease fill out the following information section and leave it in your PursuitOwner’s Manual. This information

3480 DRUMMOND RUNNER505.5 Plumbing Systems MaintenanceWATER SYSTEMSInformation supplied with water system components, by the equipment manufacture

3480 DRUMMOND RUNNER51THE FRESH AND RAW WATER SYSTEMS MUST BE PROPERLY WINTERIZED PRIORTO WINTER LAY-UP. SEE THE SECTION ON WINTERIZING.DRAINAGE SYST

3480 DRUMMOND RUNNER52Operator Notes

3480 DRUMMOND RUNNER53Chapter 6:VENTILATION SYSTEM6.1 Cabin VentilationVentilation to the cabin area and head is provided by deck hatches.DECK HATCHTh

3480 DRUMMOND RUNNER54boards. This provides adequate air movement in the bilge and generator compartments.6.5 Generator Compartment VentilationY

3480 DRUMMOND RUNNER55• Blower operation can and should be tested by placing a hand over the exhaust vent. Do not rely on thesound of the blower. A

3480 DRUMMOND RUNNER56Operator Notes

3480 DRUMMOND RUNNER57Chapter 7:EXTERIOR EQUIPMENT7.1 DeckRAILS AND DECK HARDWAREThe rail system and hardware fittings have been selected and instal

3480 DRUMMOND RUNNER58The windlass locker is drained by a thru-hull fitting. Check the drain frequently to make sure it is clean andfree flowing.

3480 DRUMMOND RUNNER597.2 HullSWIM PLATFORMYour Pursuit is equipped with an integral swim platform and engine mounting system located in the stern of

3480 DRUMMOND RUNNER6Operator Notes

3480 DRUMMOND RUNNER60The refrigerator in the cockpit island runs on DC power only. Care should be exercised while operating therefrigerator on 1

3480 DRUMMOND RUNNER61COCKPIT SHOWERA fresh water shower is located behind a small door in the cockpit. It is supplied hot and cold water by thefresh

3480 DRUMMOND RUNNER62NOTICETO PREVENT GEL CRACKING OR DAMAGE TO GUNWALES OR DECKS, SUPPORT EX-TENDING TO THE STRINGERS MAY BE REQUIRED. FIBERGLA

3480 DRUMMOND RUNNER63Chapter 8:INTERIOR EQUIPMENT8.1 Companionway DoorThe cabin is accessed through a sliding hatch and hinged door. The hatch is se

3480 DRUMMOND RUNNER64NOTICEin vacuum in the system, it automatically signals the pump to energize and bring the vacuum back to operatinglevel. T

3480 DRUMMOND RUNNER658.4 Carbon Monoxide DetectorThe Safety Equipment chapter in this manual contains important information on carbon monoxide and th

3480 DRUMMOND RUNNER66TVA flat screen TV is provided as standard equipment. Please refer to the TV owner's manual.DVDThe DVD is mounted to t

3480 DRUMMOND RUNNER67Chapter 9:SAFETY EQUIPMENT9.1 GeneralYour boat and outboard engines have been equipped with safety equipment designed to enhan

3480 DRUMMOND RUNNER689.3 Neutral Safety SwitchEvery control system has a neutral safety switch incorporated into it. This device prohibits the e

3480 DRUMMOND RUNNER69IF ACTIVATION SHOULD OCCUR, IMMEDIATELY SHUT DOWN ALL ENGINES. TURNOFF ALL ELECTRICAL SYSTEMS, POWERED VENTILATION AND EXTINGUI

3480 DRUMMOND RUNNER7CERTIFICATIONS & SPECIFICATIONS(For Export Only)Manufacturer:NameAddressZip Code:Identification Numbers:Hull Identification N

3480 DRUMMOND RUNNER70Always make sure the battery switch is “on” and the power light on the carbon monoxide detector is litwhenever the cabin is

3480 DRUMMOND RUNNER71In certain situations, boats can have a problem dueto the “station wagon effect” where engine exhaustfumes are captured in the v

3480 DRUMMOND RUNNER72Your boat should also be equipped with at least a simple marine first-aid kit and a first-aid manual. The marinefirst-aid k

3480 DRUMMOND RUNNER73• Pyrotechnic red flares, hand held or aerial.• Pyrotechnic orange smoke, hand-held or floating.• Launchers for aerial red meteo

3480 DRUMMOND RUNNER74• There is no obvious physical damage, corrosion, leakage or clogged nozzles.Refer to the “Federal Requirements And Safety T

3480 DRUMMOND RUNNER75Additional Equipment to Consider:VHF Radio Life Raft Spare Anchor Spare KeysHeaving Line Fenders First Aid Kit Portable RadioFla

3480 DRUMMOND RUNNER76Operator Notes

3480 DRUMMOND RUNNER77Chapter 10:OPERATION10.1 GeneralBefore you start the engines on your Pursuit, you should have become familiar with the various

3480 DRUMMOND RUNNER78DECKS ARE SLIPPERY WHEN WET. WEAR PROPER FOOTWEAR AND USE EXTREMECAUTION ON WET SURFACES.10.2 Rules of the RoadAs in drivin

3480 DRUMMOND RUNNER79OVERTAKING SITUATIONSWhen one motor boat is overtaking another motor boat,the boat that is being passed has the right of way. T

3480 DRUMMOND RUNNER8Operator Notes

3480 DRUMMOND RUNNER80THERE MUST BE AT LEAST ONE PERSONAL FLOTATION DEVICE ON BOARD FOR EV-ERY PERSON ON BOARD AND ONE THROW-OUT FLOTATION DEVICE.

3480 DRUMMOND RUNNER81• Be sure the emergency stop lanyard is attached to the operator and the stop switch.VAPORIZING LIQUID EXTINGUISHERS GIVE OFF TO

3480 DRUMMOND RUNNER82• Avoid sea conditions that are beyond the skill and experience of you and your crew.MAKE SURE ONE OTHER PERSON ON THE BOAT

3480 DRUMMOND RUNNER83• Check the bilge area for debris and excess water.• Fill the fuel tanks to near full to reduce condensation. Allow enough room

3480 DRUMMOND RUNNER84• Be careful when using the trim tabs from the tower. The reaction of the trim tabs will be exaggeratedin the tower. Use s

3480 DRUMMOND RUNNER85Dock lines are generally twisted or braided nylon. Nylon is strong and stretches to absorb shock. It also hasa long life and i

3480 DRUMMOND RUNNER86LEAVING A MOORINGStart the engines and let them warm up for several minutes before releasing the mooring line. The boat wil

3480 DRUMMOND RUNNER87stabilized, thoroughly inspect the boat for damage. Check below decks for leaks and the control systems forproper operation. P

3480 DRUMMOND RUNNER88If the boat becomes swamped and capsizes, you and your passengers should stay with the boat as long as youcan. It is much e

3480 DRUMMOND RUNNER89 • Make sure the trailer bunks and rollers properly support the hull and do not put pressure on the liftingstrakes. The rollers

3480 DRUMMOND RUNNER9Warranty and Warranty Registration CardsThe Pursuit Limited Warranty Statement is included with your boat. It has been written t

3480 DRUMMOND RUNNER9010.14 Water SkiingYour Pursuit could be equipped for water skiing. If you have never driven skiers before, you should spen

3480 DRUMMOND RUNNER91• Keep the person on the driver side of the boat so you can keep him in sight at all times.• Make sure to approach the person fr

3480 DRUMMOND RUNNER92Operator Notes

3480 DRUMMOND RUNNER93Chapter 11:ROUTINE MAINTENANCE11.1 GeneralBEFORE USING A CLEANING PRODUCT, REFER TO THE PRODUCT DIRECTIONS ANDSPECIFICATIONS.IF

3480 DRUMMOND RUNNER94Do not allow the hull antifouling paint to contact the outboard motor. Most antifouling paints designed forhull bottoms con

3480 DRUMMOND RUNNER95USE EXTREME CARE WHEN WALKING ON WET GELCOAT SURFACES AS THEY ARESLIPPERY.STAINLESS STEEL HARDWAREWhen using the boat in saltwat

3480 DRUMMOND RUNNER96YOU SHOULD CONTACT PURSUIT CUSTOMER RELATIONS BEFORE MAKING ANYMODIFICATIONS TO ALUMINUM FABRICATIONS. UNAUTHORIZED MODIFIC

3480 DRUMMOND RUNNER97CORIAN® SURFACESAlthough Corian® is quite resistant to heat, you should always use a hot pad or a trivet with rubber feet toprot

3480 DRUMMOND RUNNER98become badly soiled. Dirt, oil, mildew, and cleaning agents containing ammonia will shorten the life of thevinyl that is us

3480 DRUMMOND RUNNER9911.5 BilgeTo keep the bilge clean and fresh, use a commercial bilge cleaner regularly. Follow the directions carefully.All exp